2009 Newmar Ventana Dp recalls

NEWMAR IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200 SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

NEWMAR IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE SAFETY RECALL BEGAN ON MARCH 28, 2011. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101.

NEWMAR IS RECALLING 109 MY 2008-2009 BAY STAR, CANYON STAR KOUNTRY AIRE, TORREY PINE, VENTANA DIESEL PUSHER, ALL STAR DIESEL PUSHER, KOUNTRY STAR DIESEL PUSHER, AND DUTCH STAR DIESEL PUSHER CLASS A MOTOR HOMES AND FIFTH WHEEL TRAVEL TRAILERS EQUIPPED WITH ATWOOD SEALED BURNER RANGES. THE RANGE AND SLIDE-IN BURNER TUBES LEADING FROM THE GAS MANIFOLD TO THE BURNER HEADS HAD A DEPRESSION OR "KINK" IN THE EXTERIOR BEND RESTRICTING PROPER AIRFLOW AND GAS MIXTURE.

THIS CONDITION COULD RESULT IN CARBON MONOXIDE POISONING.

NEWMAR IS WORKING WITH ATWOOD TO HAVE THE TUBES REPLACED ON THESE RANGES (PLEASE SEE 07E030). OWNERS MAY CONTACT ATWOOD AT 1-800-348-7418 OR NEWMAR AT 574-773-7791.

NEWMAR IS RECALLING 148 MY 2008-2009 VENTANA DP MOTOR HOMES. AFTER SOME PERIOD OF USE AND DUE TO THE UNSHIELDED PROXIMITY OF THE PRIMARY ENGINE EXHAUST SYSTEM, THERMAL BREAKDOWN OF THE POLYETHYLENE MOISTURE BARRIER MAY OCCUR AND COULD RESULT IN AUTO-IGNITION AND COMBUSTION.

THE LOCATION OF THE MOISTURE BARRIER (ON THE UNDERSIDE OF THE MAIN FLOOR ABOVE THE ENGINE COMPARTMENT), IN RELATION TO THE UNSHIELDED PRIMARY ENGINE EXHAUST SYSTEM, MAY PRESENT A FIRE HAZARD.

DEALERS WILL ADD THE OMITTED HEAT SHIELD. THE RECALL IS EXPECTED TO BEGIN DURING SEPTEMBER 2008. OWNERS MAY CONTACT NEWMAR AT 1-574-773-7791.

NEWMAR IS RECALLING 328 MODEL YEAR 2008 THROUGH 2010 RECREATIONAL VEHICLES MANUFACTURED BETWEEN APRIL 16, 2007 AND APRIL 22, 2009. AN INADVERTENT DEVIATION IN GROUND CABLE SIZING OCCURRED RESULTING IN WIRE GAUGE UNDERSIZING.

UNDERSIZED ELECTRICAL CONDUCTORS MAY RESULT IN CONDUCTOR FAILURE, CREATING A SHOCK OR FIRE HAZARD WITHOUT WARNING.

NEWMAR WILL NOTIFY OWNERS AND PROVIDE A FREE REMEDY. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING AUGUST 2009. OWNERS MAY CONTACT NEWMAR AT 1-574-773-7791.

NEWMAR IS RECALLING 63 MODEL YEAR 2009 AND 2010 RECREATIONAL VEHICLES MANUFACTURED BETWEEN JULY 21, 2008 AND APRIL 22, 2009, EQUIPPED WITH CERTAIN HALDEX QUICK RELEASE VALVES (QRV). THE RUBBER DIAPHRAGM INSIDE THE QRV MAY EXPERIENCE DELAMINATION RESULTING IN SIGNIFICANT LEVELS OF AIR PRESSURE LEAKAGE PAST AND/OR THROUGH THE DIAPHRAGM, OR THE DEVELOPMENT OF A BUBBLE IN THE DIAPHRAGM WHICH MAY TRAP AIR PRESSURE IN THE VALVE AND NOT ALLOW THE SERVICE BRAKES TO RELEASE.

MALFUNCTION OF THE AIR BRAKE SYSTEM COULD RESULT IN A VEHICLE CRASH.

NEWMAR WILL NOTIFY OWNERS AND SPARTAN WILL PROVIDE A FREE REMEDY. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING JULY 2009. OWNERS MAY CONTACT SPARTAN CHASSIS TOLL-FREE AT 1-800-543-4277 OR NEWMAR AT 1-574-773-7791.

NEWMAR IS RECALLING 913 MY 2007-2009 ALL STAR ME, DUTCH STAR DP, MY 2007-2008 KOUNTRY STAR DP, MY 2007 MOUNTAIN AIRE DP, AND MY 2009 DUTCH AIRE DP AND VENTANA DP MOTOR HOMES BUILT ON SPARTAN CHASSIS AND EQUIPPED WITH PUTNAM HITCHES. AFTER SOME PERIOD OF USE, CERTAIN TRAILER HITCHES MAY DEVELOP STRESS FRACTURES DUE TO SHARP RADII AND /OR TOOL MARKING.

FRACTURES IN THE SUSPECT HITCHES MAY RESULT IN HITCH SEPARATION, POTENTIALLY RESULTING IN INJURY AND/OR PROPERTY DAMAGE.

NEWMAR IS WORKING WITH SPARTAN WHO WILL REPLACE THE TRAILER HITCH FREE OF CHARGE (PLEASE SEE 08V567). OWNERS MAY CONTACT SPARTAN AT 1-517-543-6400 OR NEWMAR AT 1-574-773-7791.

NEWMAR IS RECALLING CERTAIN MOTOR HOMES BUILT ON SPARTAN MOTOR HOME CHASSIS. CERTAIN CHASSIS FASTENERS MAY FRACTURE RESULTING IN POOR HANDLING OF THE VEHICLE, LOSS OF STEERING, AND/OR REDUCED LEVEL OF SUSPENSION PERFORMANCE.

LOSS OF STEERING WILL INCREASE THE RISK OF A CRASH.

NEWMAR IS WORKING WITH SPARTAN TO HAVE THESE MOTOR HOMES INSPECTED AND THE FASTENERS REPLACED AS NEEDED FREE OF CHARGE. OWNERS MAY CONTACT SPARTAN CHASSIS AT 1-800-543-4277 OR NEWMAR AT 1-574-773-7791.