2009 Fccc B2 recalls

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 THOMAS BUILT SAF-T-LINER C2 AND SAF-T-LINER HDX SCHOOL BUSES AND FCCC B2 BUS CHASSIS USED IN SAF-T-LINER C2 SCHOOL BUSES MANUFACTURED FROM AUGUST 18, 2006, THROUGH JULY 7, 2010, EQUIPPED WITH EPA 2007 MBE 900 DETROIT DIESEL ENGINES. ENGINE SOFTWARE MAY NOT REACT PROPERLY TO CERTAIN AFTERMARKET TREATMENT DEVICE FAULT CODES. THE SOFTWARE MAY UNNECESSARILY SHUTDOWN A VEHICLE OR MAY FAIL TO SHUTDOWN A VEHICLE WITH AN AFTERMARKET DEVICE OVER-TEMP FAULT.

UNEXPECTED SHUTDOWN OF A VEHICLE MAY INCREASE THE RISK OF A CRASH. OVERHEATING OF THE AFTERTREATMENT DEVICE WITHOUT ENGINE SHUTDOWN MAY RESULT IN A FIRE.

DAIMLER TRUCKS WILL NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY DETROIT DIESEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 25, 2011. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712. THIS SAFETY RECALL CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 10V-468).

DAIMLER TRUCKS IS RECALLING 1,460 MODEL YEAR 2009 AND 2010 HEAVY DUTY TRUCKS AND FCCC CHASSIS (USED ON THOMAS BUILT SCHOOL BUSES) MANUFACTURED FROM JUNE 11 THROUGH DECEMBER 16, 2008, EQUIPPED WITH CERTAIN HALDEX QUICK RELEASE VALVES (QRV). THE RUBBER DIAPHRAGM INSIDE THE QRV MAY EXPERIENCE DELAMINATION RESULTING IN SIGNIFICANT LEVELS OF AIR PRESSURE LEAKAGE PAST AND/OR THROUGH THE DIAPHRAGM, OR THE DEVELOPMENT OF A BUBBLE IN THE DIAPHRAGM WHICH MAY TRAP AIR PRESSURE IN THE VALVE AND NOT ALLOW THE SERVICE BRAKES TO RELEASE.

MALFUNCTION OF THE AIR BRAKE SYSTEM COULD RESULT IN A VEHICLE CRASH.

DAIMLER TRUCKS WILL NOTIFY OWNERS AND REPAIR THE BUSES FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY DAIMLER TRUCKS NORTH AMERICA. THE SAFETY RECALL BEGAN ON AUGUST 12, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2010 THOMAS BUILT SAF-T-LINER C2 SCHOOL BUSES AND FCCC B2 CHASSIS MANUFACTURED FROM OCTOBER 1, 2007 THROUGH AUGUST 10, 2009, EQUIPPED WITH CUMMINS ISB CM2150 J1939/1587 ENGINE CONTROL UNIT, BOSCH HYDRAULIC PIN-SLIDE FRONT BRAKES, AND WEBASTO 17K BTU COOLANT HEATER. THE FRONT RIGHT HAND CROSSOVER BRAKE LINE MAY HAVE BEEN SECURED USING SHORTER OFFSET THAN SPECIFIED CLAMPS POTENTIALLY ALLOWING THE BRAKE LINE TO RUB ON THE SURROUNDING COMPONENTS. THIS MAY LEAD TO A BRAKE FLUID LEAK.

CONTINUED CONTACT BETWEEN THE BRAKE LINE AND THE SURROUNDING COMPONENTS MAY LEAD TO A LOSS OF BRAKE FLUID AND REDUCE BRAKING PERFORMANCE POTENTIALLY RESULTING IN A VEHICLE CRASH.

DAIMLER TRUCKS WILL NOTIFY OWNERS. DEALERS WILL INSPECT THE UNITS AND CLAMPS WITH SHORTER OFFSET THAN SPECIFIED WILL BE REPLACED WITH LONGER OFFSET CLAMPS. ANY BRAKE LINES FOUND TO BE DAMAGED WILL BE REPLACED. REPAIRS WILL BE DONE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 23, 2010. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 THOMAS BUILT SAF-T-LINER C2 SCHOOL BUSES AND FCCC B2 CHASSIS MANUFACTURED FROM JUNE 1, 2007 THROUGH SEPTEMBER 28, 2009. FASTENERS USED TO CONNECT THE REAR SUSPENSION SPRING TO THE SUSPENSION HANGER BRACKET MAY NOT HAVE BEEN TORQUED TO SPECIFICATION. UNDER TORQUED FASTENERS MAY BECOME LOOSE AND POTENTIALLY FALL OUT.

LOOSE OR MISSING FASTENERS MAY ALLOW THE REAR SUSPENSION TO BECOME MISALIGNED, INCREASING THE RISK OF A CRASH.

DEALERS WILL INSPECT AND ADJUST THE FASTENERS AS REQUIRED. DAMAGED FASTENERS WILL BE REPLACED. REPAIRS WILL BE MADE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING FEBRUARY 2010. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.

DAIMLER TRUCKS IS RECALLING 15,686 MY 2005 THROUGH 2009 FCCC AND THOMAS BUILT SCHOOL AND TRANSIT BUSES MANUFACTURED BETWEEN MARCH 2005 AND MAY 2008 EQUIPPED WITH A CERTAIN BRAKE LAMP AIR PRESSURE SWITCH. THE CONTACTS IN THE PRESSURE SWITCH FOR THE LOW CURRENT BRAKE LAMP SIGNAL TO THE CHASSIS ECU MAY HAVE BECOME CONTAMINATED BY SILICONE DURING ASSEMBLY CAUSING INSULATING DEPOSITS TO BUILD UP OVER TIME PREVENTING THE BRAKE LAMPS FROM OPERATING.

INOPERATIVE BRAKE LAMPS WOULD NOT PROVIDE A SIGNAL TO FOLLOWING DRIVERS THAT THE BRAKES ARE APPLIED AND A CRASH MAY OCCUR.

DAIMLER TRUCKS WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE PRESSURE SWITCH FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT MARCH 18, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712 OR THOMAS BUILT BUSES AT 1-336-889-4871.

DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2011 FCCC B2 106 CH AND THOMAS BUILT SAF-T-LINER C2 AND HDX SCHOOL BUSES MANUFACTURED FROM SEPTEMBER 5, 2006 THROUGH JUNE 30, 2010, EQUIPPED WITH SPECIFIC MBE900 EPA04 AND EPA07 MODEL ENGINES. THE INTAKE AIR GRID HEATER MAY SHORT CIRCUIT AND FAIL DUE TO EXCESSIVE INTERNAL TEMPERATURES.

A SHORT CIRCUITED GRID HEATER COULD RESULT IN A VEHICLE FIRE AND INJURY TO VEHICLE OCCUPANTS.

DAIMLER TRUCKS WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE BUSES FREE OF CHARGE. REPAIRS WILL BE PERFORMED BY DETROIT DIESEL CORPORATION AUTHORIZED REPAIR FACILITIES. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT JULY 29, 2011. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.

DTNA IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2011 FREIGHTLINER BUSINESS CLASS C2, FCCC B2 CHASSIS, S2 CHASSIS, AND MC CHASSIS MANUFACTURED BEGINNING JANUARY 19, 2005 THROUGH APRIL 16, 2010. THE STOP LAMPS MAY BE INTERMITTENT DURING LIGHT BRAKE APPLICATIONS.

THE STOP LAMPS MAY NOT PROPERLY INDICATE THAT THE SERVICE BRAKES ARE APPLIED WHICH MAY LEAD TO A CRASH WITHOUT WARNING.

DTNA WILL NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY DTNA DEALERSHIPS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2011. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.