1999 COUNTRY COACH Magna recalls

CERTAIN MOTOR HOMES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THESE MOTOR HOMES WERE ERRONEOUSLY ASSIGNED INADEQUATE TIRE INFLATION PRESSURES AND INADEQUATE AXLE WEIGHT RATINGS ON THE FRONT AND/OR REAR AXLES AS A RESULT OF MATHEMATICAL MISCALCULATIONS. THESE MOTOR HOMES HAVE TIRE WEIGHT RATINGS THAT ARE LESS THAN THE FRONT OR REAR AXLE WEIGHT RATINGS (FRONT AXLE WEIGHT RATING:FAWR AND REAR AXLE WEIGHT RATINGS:RAWR) AND IN SOME INSTANCES HAVE INADEQUATE FAWR AND/OR RAWR.

AS A CONSEQUENCE, THE TIRES SELECTED FOR THESE MOTOR HOMES DO NOT COMPLY WITH THE STANDARD. IN SOME CASES, THIS NONCOMPLIANCE COULD CAUSE PREMATURE FRONT TIRE TREAD WEAR OR TIRE FAILURE DURING NORMAL DRIVING. THE PREMATURE TIRE TREAD WEAR OR TIRE FAILURE COULD LEAD TO A LOSS OF STEERING CONTROL.

DEALERS WILL REMOVE THE FRONT AND/OR REAR TIRES AND REPLACED. FEDERAL TIRE LABELS WILL ALSO BE REPLACED. OWNER NOTIFICATION BEGAN NOVEMBER 8, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COUNTRY COACH AT 1-800-452-8015.

CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THE FRONT AXLE RATING IS INCORRECT.

THIS COULD CAUSE PREMATURE TIRE TREAD WEAR OR TIRE FAILURE DURING NORMAL DRIVING. THE PREMATURE TIRE TREAD WEAR OR TIRE FAILURE COULD LEAD TO A LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.

DEALERS WILL REPLACE BOTH FRONT TIRES AND THE FRONT AXLE WILL BE RE-RATED TO 12,000 LBS. ALL MOTOR HOMES WILL BE ISSUED NEW FEDERAL TIRE LABELS. OWNER NOTIFICATION IS EXPECTED TO BEGIN FEBRUARY 10, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COUNTRY COACH AT 1-800-547-8015.

VEHICLE DESCRIPTION: MOTOR HOMES. MISALIGNMENT OF THE MOTOR HOMES' FRONT BRAKE HOSES DURING SHARP TURNING MOVEMENTS CAN WEAKEN THE HOSES THROUGH RUBBING AND/OR CHAFFING ON THE STEERING TIRES OR COMPONENTS OF THE FRAME. A SUDDEN LOSS OF BRAKING ON A STEERING WHEEL COULD OCCUR IF THE HOSE RUPTURES, CAUSING THE MOTOR HOME TO PULL SHARPLY TO ONE SIDE.

A LOW AIR SITUATION COULD DEVELOP AND RESULT IN THE APPLICATION OF THE REAR SPRING BRAKES RESULTING IN A SUDDEN STOP INCREASING THE RISK OF A CRASH.

DEALERS WILL REPLACE AND RE-ROUTE THE FRONT BRAKE HOSES. OWNER NOTIFICATION BEGAN NOVEMBER 26, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COUNTRY COACH AT 1-800-452-8015.

VEHICLE DESCRIPTION: MOTOR HOMES EQUIPPED WITH 16,000 LB., 18,000 LB., OR 20,000 LB. HEAVY DUTY STEERING AXLES. THE INNER WHEEL BEARING CONE FOR THE STEERING AXLE WHEEL HUB ASSEMBLY DOES NOT PROPERLY FIT ONTO THE NAVISTAR STEERING AXLE SPINDLE ASSEMBLY. IMPROPER FIT OF THE BEARING TO THE SPINDLE INCREASES THE STRESS LEVELS TO THE STEERING AXLE SPINDLE WHICH COULD CAUSE SPINDLE FAILURE.

IF THE SPINDLE FAILS, A LOSS OF DRIVER CONTROL COULD OCCUR, INCREASING THE RISK OF A VEHICLE CRASH.

DEALERS WILL REMOVE THE LEFT AND RIGHT HUB/DRUM ASSEMBLIES FROM THE STEERING AXLES AND REPLACE THE INNER WHEEL BEARING CONES AND CUPS.

COUNTRY COACH HAS REPORTED THAT THE TOYO 275/70R M102Z TIRES ON CERTAIN MOTOR HOMES ARE DEFECTIVE AND COULD FAIL UNEXPECTEDLY.

THIS COULD CAUSE A LOSS OF VEHICLE CONTROL INCREASING THE RISK OF A CRASH.

DEALERS WILL REPLACE THESE TIRES WITH MICHELIN 275/70R XZA2 TIRES. THE FEDERAL TIRE LABELS WILL ALSO BE REPLACED. THE RECALL BEGAN ON NOVEMBER 8, 2006. OWNERS MAY CONTACT COUNTRY COACH AT 1-800-547-8015.

CERTAIN MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.

COUNTRY COACH WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). A SECONDARY BURNER HOUSING WILL BE INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON MARCH 28, 2007. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR COUNTRY COACH AT 1-800-452-8015.