1995 Orion Vi recalls

DAIMLER BUS IS RECALLING CERTAIN MODEL YEAR 1995 THROUGH 2000 TRANSIT BUSES MANUFACTURED FROM JANUARY 1996 THROUGH DECEMBER 2000. THESE BUSES ARE CONFIGURED WITH A TAPPED FITTING FOR THE HYDRAULIC WHEELCHAIR RAMP. IN THE ENGINE COMPARTMENT CONNECTED TO THE HYDRAULIC PUMP IS A FITTING WITH AN ADAPTER FOR THE WHEELCHAIR RAMP OPERATION. THE FITTING CAN CRACK AND CAUSE HYDRAULIC FLUID TO LEAK INTO THE ENGINE COMPARTMENT.

HYDRAULIC FLUIDS LEAKING INTO THE ENGINE COMPARTMENT CAN BE IGNITED BY THE HOT TURBOCHARGER AND CAUSE AN ENGINE FIRE.

BUS OWNERS WILL BE INSTRUCTED ON HOW TO REPAIR THE BUSES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON 3, DECEMBER 2010. OWNERS MAY CONTACT DAIMLER BUSES AT 1-800-716-7566.

CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE." THE HANDLE PULL FORCE EXCEEDS THE 89N FORCE TO RELEASE THE EMERGENCY WINDOW. ADDITIONAL FORCE IS REQUIRED TO RELEASE THE WINDOW.

IN THE EVENT OF A CRASH, AN OCCUPANT MAY HAVE DIFFICULTY OPENING THE EMERGENCY EXIT WINDOW, INCREASING THE RISK OF PERSONAL INJURY OR DEATH.

DEALERS WILL REPAIR THESE WINDOWS. OWNER NOTIFICATION BEGAN JUNE 1, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT ORION AT 1-800-492-2116.

THE SUBJECT VEHICLES HAVE THEIR WHEELCHAIR BARRIERS ATTACHED TO THE FLOOR STRUCTURE WITH A BOLT THREADED INTO THE FLOOR STRUCTURE. IN THE CASE OF A FRONTAL CRASH, AT MORE THAN 20 MILES PER HOUR, WITH THE WHEELCHAIR POSITION OCCUPIED, THERE IS A POSSIBLY THAT THE BOLT THREADS TAPPED INTO THE FLOOR STRUCTURE WOULD STRIP ALLOWING MOVEMENT OF THE WHEELCHAIR BARRIER.

FAILURE OF THE HARDWARE ATTACHMENT WOULD ALLOW MOVEMENT OF THE WHEELCHAIR BARRIER WHICH COULD CAUSE INJURIES, OR DEATH OF THE DISABLED PERSON OR OTHER PASSENGERS.

THE EXISTING WHEELCHAIR BARRIER LEG MOUNTING BOLTS WILL BE REPLACED WITH NEW BOLTS, WASHERS AND NUTS.

DAIMLER BUSES IS RECALLING CERTAIN ORION TRANSIT BUSES EQUIPPED WITH THE MORSE REMOTE THROTTLE CONTROL. THE MORSE REMOTE THROTTLE CONTROL PANEL IS LOCATED IN THE ENGINE COMPARTMENT AND A SWITCH ON IT IS LABELED, "THROTTLE"; "OFF" OR "FRONT" AND "ON" OR "REAR" SELECTING THE ACTIVE ENGINE CONTROL STATION. IF A PERSON OPERATING THE ENGINE FROM THE "REAR" POSITION (AT THE ENGINE) FAILS TO PLACE THE SWITCH IN THE "OFF" OR "FRONT" POSITION AND THE ENGINE RPM WAS SET TO ABOVE IDLE DURING MAINTENANCE FOR EXAMPLE, WHEN THE BUS IS STARTED FROM THE DRIVER'S STATION THE ENGINE COULD CHANGE TO THE HIGHER RPM RESULTING IN UNWANTED ENGINE POWER.

THE BUS COULD ACCELERATE AT A HIGHER RATE THAN ANTICIPATED INCREASING THE RISK OF A CRASH.

DAIMLER WILL PROVIDE INSTRUCTIONS TO MODIFY THE WIRING TO THE MORSE THROTTLE CONTROL SWITCH. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 1, 2010. OWNERS MAY CONTACT DAIMLER BUSES AT 1-800-716-7466.