1993 Thomas Conventional recalls

VEHICLE DESCRIPTION: CERTAIN SCHOOL BUSES EQUIPPED WITH A STORAGE COMPARTMENT OVERHEAD TO THE LEFT OF THE DRIVER FAIL TO MEET FMVSS NO. 222, "SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION."

CONTACT WITH THIS STORAGE COMPARTMENT DOES NOT MEET THE IMPACT ZONE REQUIREMENTS OF THE STANDARD.

DEALERS WILL ADD PADDING TO THE SIDES OF THE STORAGE COMPARTMENT. OWNER NOTIFICATION BEGAN FEBRUARY 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT THOMAS BUILT AT 1-336-889-4871.

VEHICLE DESCRIPTION: SCHOOL BUSES EQUIPPED WITH OUTWARD OPENING SERVICE DOORS. THE POSSIBILITY EXISTS FOR AN ITEM WORN BY A CHILD, SUCH AS A LONG DRAWSTRING, SASH, OR BACKPACK/BOOKBAG ACCESSORY, CAN BECOME CAUGHT IN A SMALL OPENING AT THE FLOOR LEVEL OF THE FORWARD DOOR POST.

IF AN ITEM WORN BY A CHILD WERE TO CATCH IN THE OPENING, AND THE DRIVER WERE TO CLOSE THE DOOR AND PUT THE VEHICLE IN MOTION, IT COULD RESULT IN INJURY OR DEATH TO THE CHILD.

DEALERS WILL INSPECT THE FORWARD DOOR POST TO VERIFY THAT THE OPENING IS COMPLETELY ELIMINATED, AND IF NECESSARY, WILL INSTALL SEALANT IN ANY REMAINING PORTION OF THE OPENING.

THE CURRENT PRODUCTION STATIONARY WINDOW ASSEMBLIES ALLOW THE GLASS TO DISENGAGE FROM THE RUBBER AND/OR FRAME.

THE WINDOWS DO NOT COMPLY WITH FMVSS 217, "BUS WINDOWRETENTION AND RELEASE."

INSTALL TWO RETAINING CLIPS AT EACH NON-COMPLYING WINDOW.

AN ITEM WORN BY A CHILD, SUCH AS A LONG DRAWSTRING, SASH, OR BACKPACK/BOOKBAG ACCESSORY, CAN BECOME CAUGHT IN THE AREA BETWEEN THE SERVICE DOOR AND THE DOOR CONTROL ROD ATTACHING BRACKET.

IF AN ITEM WORN BY A CHILD WERE TO CATCH ON THIS AREA, AND THE DRIVER WERE TO CLOSE THE DOOR AND PUT THE VEHICLE IN MOTION, THIS CAN RESULT IN SERIOUS INJURY OR DEATH.

A MOLDED COVER WILL BE INSTALLED BETWEEN THE MANUALLY OPERATED OUTWARD OPENING ENTRANCE DOOR AND THE DOOR CONTROL ROD ATTACHING BRACKET WHICH WILL ELIMINATE THE OPENING THAT COULD ALLOW AN ITEM OF A CHILD'S CLOTHING TO BECOME SNAGGED.

AN ITEM WORN BY A CHILD, SUCH AS A LONG DRAWSTRING, SASH, OR BACKPACK/BOOKBAG ACCESSORY CAN BECOME CAUGHT IN A SMALL OPENING AT THE FLOOR LEVEL OF THE FORWARD DOOR POST.

A PASSENGER'S CLOTHING COULD BECOME CAUGHT IN THE SMALL OPENING AND IF THE BUS DRIVER CLOSES THE DOOR AND PUTS THE VEHICLE IN MOTION, THE INDIVIDUAL IS SUBJECT TO BEING DRAGGED BY THE BUS. THIS CAN RESULT IN SERIOUS INJURY OR DEATH.

A FILLER PLATE WILL BE ATTACHED ON THOMAS CONVENTIONALS OR A PIECE OF RUBBER TRIM ON THOMAS VISTAS TO THE FORWARD DOOR POST AT THE FLOOR LEVEL TO COVER THE OPENING AND ELIMINATE THE POSSIBILITY OF SNAGGING.

VEHICLE DESCRIPTION: SCHOOL BUSES BUILT ON A NAVISTAR CHASSIS. THE CROSS VIEW MIRRORS DO NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 111, "REARVIEW MIRRORS." THE ENTIRE TOP SURFACE OF CYLINDER H IS NOT VISIBLE AS REQUIRED.

A DRIVER MAY NOT BE ABLE TO SEE CERTAIN PORTIONS OF THE BUS INCREASING THE RISK OF A CRASH OR PERSONAL INJURY TO PERSONS NEAR THE BUS.

OWNERS WILL BE PROVIDED WITH A REPAIR KIT AND DETAILED INSTRUCTIONS. IF AN OWNER SO DESIRES, THOMAS BUILT DEALERS CAN PERFORM THE REPAIR FOR THEM.

THE METAL HOUSING OF THE SAFETY BELT RETRACTORS ON AUTOMATIC LOCKING RETRACTOR/EMERGENCY LOCKING RETRACTOR SAFETY BELTS CAN BECOME DEFORMED PREVENTING EXTENSION AND/OR RETRACTION OF THE BELT.

PASSENGERS WOULD BE UNABLE TO EXTEND OR RETRACT THEIR SAFETY BELTS AND WOULD BE AT A RISK OF INJURY IN THE EVENT OF AN ACCIDENT.

DEALERS WILL INSTALL A HARDENED WASHER WHICH WILL DECREASE THE POSSIBILITY OF DEFORMATION OF THE SAFETY BELT RETRACTOR. DAMAGED RETRACTORS WILL BE REPLACED.