1976 Volkswagen Rabbit recalls

CERTAIN HYDRAULIC BRAKE HOSES, P/N 171.611.107B, SOLD AS REPLACEMENT EQUIPMENT FOR 1975-1985 VOLKSWAGEN (VW) RABBIT; 1985-1992 VW GOLF; AND 1980-1992 VW JETTA PASSENGER VEHICLES. POSSIBLE BRAKE HOSE RUPTURE COULD OCCUR WHICH FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 106, "BRAKE HOSES."

BRAKE HOSE RUPTURE COULD RESULT IN LOSS OF BRAKING ABILITY, POSSIBLY RESULTING IN A VEHICLE CRASH.

FOREIGN PARTS DISTRIBUTORS WILL NOTIFY OWNERS AND REPLACE THE BRAKE HOSES WITH COMPLIANT BRAKE HOSES. THE RECALL BEGAN ON MARCH 30, 2006. OWNERS MAY CONTACT FOREIGN PARTS DISTRIBUTORS AT 305-885-8646 EXT. 11.

BRAKE LINES INSTALLED UNDERNEATH THE CARPETING IN THE PASSENGER COMPARTMENT MAY RUST DUE TO THE ENTRY OF WATER AND ROAD SALT. IF RUSTING REMAINS UNCHECKED, IT PRODUCES LEAKS IN THE LINES AND BRAKE FLUID MAY BE LOST.

THE DEALER WILL INSPECT AND, IF NECESSARY, REPLACE THE INTERIOR BRAKE LINES AT NO COST TO OWNER. OWNERS ARE ALSO ADVISED THAT ALL BRAKE LINES SHOULD BE INSPECTED AT TWO-YEAR INTERVALS.

ON SOME VEHICLES, THE FENDER OPENING THROUGH WHICH THE ANTENNA CABLE IS ROUTED MAY NOT BE PROPERLY SEALED. AS A RESULT, SPLASHED WATER FROM THE TIRES COULD ENTER PASSENGER COMPARTMENT THROUGH THE OPENING, ENTER THE FUSE RELAY BOARD AND CAUSE CORROSION OF THE TERMINALS. ALSO, BECAUSE WATER IS A GOOD CONDUCTOR OF ELECTRICITY, THE STARTER CAN BE ACTIVATED ACCIDENTALLY; THE HIGH FLOW OF ELECTRICITY MAY EXHAUST THE BATTERY WITHIN A SHORT PERIOD OF TIME. THUS RESTARTING THE ENGINE WOULD BECOME IMPOSSIBLE AND PARKING LIGHTS AND EMERGENCY FLASHERS WOULD BECOME INOPERATIVE.

DEALER WILL INSPECT AND, IF NECESSARY, SEAL THE RADIO ANTENNA HOLES AND REPLACE CORRODED COMPONENTS WITHOUT CHARGE TO OWNER..

THE ACCELERATOR CABLE ASSEMBLY IN THE INVOLVED VEHICLES COULD FAIL PREMATURELY UNDER CERTAIN OPERATING CONDITIONS. THIS WOULD EITHER PREVENT THE ACCELERATOR PEDAL FROM RETURNING TO THE IDLE POSITION OR CAUSE A LOSS OF ADEQUATE ENGINE POWER.

DEALER WILL INSPECT AND, IF NECESSARY, INSTALL A NEW ACCELERATOR CABLE, WITHOUT CHARGE TO OWNER.

DUE TO AN IMPROPERLY SEALED ANTENNA MOUNTING HOLE, WATER COULD SEAP INTO THE FUSE RELAY BOARD. THE WATER ENTERING THE FUSE RELAY BOARD ACTS AS A CONDUCTOR OF CURRENT, THEREBY CHARGING THE STARTER.

THE DEALER WILL SEAL ALL RADIO ANTENNA CABLE HOLES. IN ADDITION, ELECTRICAL PARTS OF THE RELAY/FUSE BOARD WILL BE CHECKED AND REPLACED IN THE CASE OF CORROSION.

THE INVOLVED VEHICLES DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC BRAKE SYSTEMS". THE INVOLVED VEHICLES WERE INADVERTENTLY EQUIPPED WITH A BRAKE FLUID CONTAINER CAP ON WHICH THE WARNING TEXT WAS PRINTED IN GERMAN.

THE DEALER WILL INSTALL A SUPPLEMENT LABEL, PRINTED IN ENGLISH, ON THE BRAKE FLUID CONTAINER, DISPLAYING THE REQUIRED STATEMENT, FREE OF CHARGE.